Implementation of an Automatic Controlled Power Factor Correction System Utilizing Low-Cost Modules
DOI:
https://doi.org/10.12928/biste.v8i1.14215Keywords:
Power Factor Correction, PIC Microcontroller, Capacitor Bank, Signal Conditioning, Automatic Control, Analog ModuleAbstract
This paper presents the design and implementation of a PIC microcontroller-based power factor correction system using a stepped capacitor bank and low-cost analog measurement modules. The proposed design aimed to address the low power factor issue caused by inductive loads that intern increases the current, losses, and apparent power demand. The developed PIC-based controller integrated analog conditioning circuits for voltage, current, and phase-angle measurement. The proposed system acquires analog signals from a voltage transformer, a current transformer–op-amp module, and an AD8302-based phase detector, computes real, reactive, and apparent power in real time, and automatically connects or disconnects capacitor-bank steps to maintain the power factor within a predefined band (0.92–0.98). Experimental results on a 4 kW inductive load array indicated that the measurement error of the analog voltage module was approximately 1.32%, while the analog current module exhibited an error of around 3.02% in comparison to digital measuring instruments. Additionally, there was an improvement in the power factor from 0.865 to 0.935, with by a reduction in load current of approximately 7% and a decrease in load reactive power of about 35%. The proposed design confirms satisfactory operation for automatic capacitor-bank control in power factor correction applications.
References
C. M. Coman, A. Florescu, and C. D. Oancea, "Improving the efficiency and sustainability of power systems using distributed power factor correction methods," Sustainability (Switzerland), vol. 12, no. 8, pp. 1-20, 2020, p. 3134, 2020, https://doi.org/10.3390/su12083134.
I. Surya and J. Kustija, "Dashboard for Industrial Load Control and Remote Power Factor Correction Based on Adafruit's MQTT," Buletin Ilmiah Sarjana Teknik Elektro, vol. 5, no. 1, pp. 76-85, 2023, https://doi.org/10.12928/biste.v5i1.7494.
W. A. Salah, A. B. Musa, B. A. Zneid, A. Abu Sneineh, and M. S. Jadin, "Implementation of virtual instruments as a power quality analysis tool," Journal of Low Power Electronics, vol. 12, no. 2, pp. 83-90, 2016, https://doi.org/10.1166/jolpe.2016.1435.
G. Adedayo Ajenikoko, O. Adigun, and A. Olayinka Rafiu, "Control Techniques and Power Factor Correction Methods: A Review," Journal of Engineering Research and Reports, vol. 2, no. 1, pp. 1-13, 2018, https://doi.org/10.9734/jerr/2018/v2i19883.
A. A. Al-Muhanna, M. A. Abido, and F. S. Al-Ismail, "Assessing Impact of Optimally Placed Power Factor Correction Capacitors Reckoning Transient Switching Events," Arabian Journal for Science and Engineering, vol. 46, no. 2, pp. 1269-1277, 2021, https://doi.org/10.1007/s13369-020-04996-4.
C. M. Coman, A. Florescu, and C. D. Oancea, "Improving the Efficiency and Sustainability of Power Systems Using Distributed Power Factor Correction Methods," Sustainability, vol. 12, no. 8, 2020, https://doi.org/10.3390/su12083134.
A. Quiroga, J. Bayona, and H. Espitia, "Review of Converter Circuits with Power Factor Correction," Technologies, vol. 13, no. 6, 2020, https://doi.org/10.3390/technologies13060221.
W. A. Salah, M. Abuhelwa, M. Elnaggar, Y. F. Nassar, H. J. El-Khozondar, and M. J. K. Bashir, "Assessment of waste to energy approaches to compensate for the shortage in energy supply in Gaza, Palestine," Biofuels, Bioproducts and Biorefining, vol. 19, no. 6, pp. 2318-2332, 2025, https://doi.org/10.1002/bbb.70027.
M. Salem, A. Elmabruk, M. Irhouma, and I. Mangir, "Assessment of Wind Energy Potential in Western Mountain: Nalut and Yefren as Case Study," Wadi Alshatti University Journal of Pure and Applied Sciences, vol. 3, no. 1, pp. 35-42, 2025, https://doi.org/10.63318/waujpasv3i1_7.
A. Elmabruk, M. Salem, M. Khaleel, and A. Mansour, "Prediction of Wind Energy Potential in Tajoura and Mislata Cities," Wadi Alshatti University Journal of Pure and Applied Sciences, vol. 3, no. 2, pp. 125-131, 2025, https://doi.org/10.63318/waujpasv3i2_17.
I. Imbayah, A. Almiladi, M. AlKarghali, A. R. Oraibi, Y. Adraider, and H. Meshreghi, "Remote Climate Monitoring Through the Utilization of Solar Energy for Meteorological Systems," University of Zawia Journal of Engineering Sciences and Technology, vol. 3, no. 1, pp. 156-170, 2025, https://doi.org/10.26629/uzjest.2025.13.
Y. F. Nassar et al., "Estimation of CO2 emission within Libya's electricity generation sector," Next Research, vol. 2, no. 3, p. 100567, 2025, https://doi.org/10.1016/j.nexres.2025.100567.
S. Saeed and T. Siraj, "Global Renewable Energy Infrastructure: Pathways to Carbon Neutrality and Sustainability," Solar Energy and Sustainable Development Journal, vol. 13, no. 2, pp. 183-203, 2024, https://doi.org/10.51646/jsesd.v13i2.243.
E. Hakizimana, H. Umuhoza, E. Manishimwe, and V. Kayibanda, "Economic Optimization of Grid-Connected Photovoltaic Solar Systems in Industrial Energy: Case Study SULFO Ltd - Rwanda," Solar Energy and Sustainable Development Journal, vol. 13, no. 2, pp. 204-229, 2024, https://doi.org/10.51646/jsesd.v13i2.242.
M. Nyasapoh et al., "Navigating Renewable Energy Transition Challenges for a Sustainable Energy Future in Ghana," Solar Energy and Sustainable Development Journal, vol. 14, no. 1, pp. 237-257, 2025, https://doi.org/10.51646/jsesd.v14i1.479.
C. Kumar, M. Lakshmanan, S. Jaisiva, K. Prabaakaran, S. Barua, and H. H. Fayek, "Reactive power control in renewable rich power grids: A literature review," vol. 17, no. 5, pp. 1303-1327, 2023, https://doi.org/10.1049/rpg2.12674.
C. Adragna, A. Bianco, G. Gritti, and M. Sucameli, "State-of-the-Art Power Factor Correction: An Industry Perspective," Encyclopedia, vol. 4, no. 3, pp. 1324-1354, 2024, https://doi.org/10.3390/encyclopedia4030087.
D. J. Dullius et al., "Analysis of Financial Penalties for Low Power Factor in Distribution Systems With High Penetration of Photovoltaics," IEEE Access, vol. 12, pp. 169102-169123, 2024, https://doi.org/10.1109/ACCESS.2024.3493379.
M. M. A. Aziz, E. E. A. El-Zahab, and A. F. Zobaa, "Power factor and your electrical utility bill in Egypt," IEEE Transactions on Power Delivery, vol. 18, no. 4, pp. 1567-1568, 2003, https://doi.org/10.1109/TPWRD.2003.817535.
S. Chowdhury, E. Gurpinar and B. Ozpineci, "Capacitor Technologies: Characterization, Selection, and Packaging for Next-Generation Power Electronics Applications," in IEEE Transactions on Transportation Electrification, vol. 8, no. 2, pp. 2710-2720, 2022, https://doi.org/10.1109/TTE.2021.3139806.
Q. -H. Wu, Y. Lin, C. Hong, Y. Su, T. Wen and Y. Liu, "Transient Stability Analysis of Large-scale Power Systems: A Survey," in CSEE Journal of Power and Energy Systems, vol. 9, no. 4, pp. 1284-1300, 2023, https://doi.org/10.17775/CSEEJPES.2022.07110.
A. Symonds and M. Laylabadi, "Cycloconverter Drives in Mining Applications: A Typical Industrial System Is Analyzed and the Impact of Harmonic Filtering Considered," in IEEE Industry Applications Magazine, vol. 21, no. 6, pp. 36-46, 2015, https://doi.org/10.1109/MIAS.2014.2345805.
H. Soleimani, D. Habibi, M. Ghahramani, and A. Aziz, "Strengthening Power Systems for Net Zero: A Review of the Role of Synchronous Condensers and Emerging Challenges," Energies, vol. 17, no. 13, p. 3291, 2024, https://doi.org/10.3390/en17133291.
I. Bashir, A. H. Bhat, and S. Ahmad, "A review on soft switched PFC boost converter for efficient lowering of switching losses," Electric Power Systems Research, vol. 242, p. 111430, 2025, https://doi.org/10.1016/j.epsr.2025.111430.
A. Šešok and I. Pavić, "SVC Control Strategy for Transient Stability Improvement of Multimachine Power System," Energies, vol. 17, no. 17, p. 4224, 2024, https://doi.org/10.3390/en17174224.
I. Benhabsa, R. Kouadri, L. Slimani, and S. Mouassa, "Improving power system performance by integrating TCSC and SVC devices in the presence of stochastic renewable energy generators," Wind Engineering, p. 0309524X241307313, 2025, https://doi.org/10.1177/0309524X241307313.
S. Raj and B. Bhattacharyya, "Optimal placement of TCSC and SVC for reactive power planning using Whale optimization algorithm," Swarm and Evolutionary Computation, vol. 40, pp. 131-143, 2018, https://doi.org/10.1016/j.swevo.2017.12.008.
V. K. Gupta, S. K. Mishra, and R. Babu, "FACTS placement for reactive power planning with weak node constraints using an improved symbiotic search algorithm," Transactions on Energy Systems and Engineering Applications, vol. 4, no. 2, p. 524, 2023, https://doi.org/10.32397/tesea.vol4.n2.524.
V. K. Gupta and R. Babu, "Reactive power planning problem considering multiple type of FACTS in power systems," International Journal of System Assurance Engineering and Management, vol. 13, no. 4, pp. 1885-1894, 2022, https://doi.org/10.1007/s13198-021-01588-9.
A. Abaza, R. A. El-Sehiemy, M. Said, R. M. Ghoniem, and A. F. Barakat, "Implementation of an Electronically Based Active Power Filter Associated with a Digital Controller for Harmonics Elimination and Power Factor Correction," Electronics (Switzerland), vol. 11, no. 14, p. 2205, 2022, https://doi.org/10.3390/electronics11142205.
R. M. Milasi, A. F. Lynch, and Y. Li, "Adaptive control of an active power filter for harmonic suppression and power factor correction," International Journal of Dynamics and Control, vol. 10, no. 2, pp. 473-482, 2022, https://doi.org/10.1007/s40435-021-00825-0.
Y. Asadi, M. Eskandari, M. Mansouri, S. Chaharmahali, M. H. Moradi, and M. S. Tahriri, "Adaptive Neural Network for a Stabilizing Shunt Active Power Filter in Distorted Weak Grids," Applied Sciences, vol. 12, no. 16, 2022, https://doi.org/10.3390/app12168060.
C. Y. Chan, "Power Factor Correction Based on Adaptive Modified Current-Mode Control Approach," IEEE Transactions on Circuits and Systems II: Express Briefs, vol. 69, no. 3, pp. 1462-1466, 2022, https://doi.org/10.1109/TCSII.2021.3119705.
M. Dreidy, W. salah, and M. Safarini, "Development of an Optimal Control Strategy of Three Phase Power Factor Correction System," Solar Energy and Sustainable Development Journal, vol. 14, no. 2, pp. 74-96, 09/09 2025, https://doi.org/10.51646/jsesd.v14i2.660.
V. Aviña-Corral, J. Rangel-Magdaleno and J. Hernandez-Perez, "63-Level Asymmetric Capacitor an Inductor Bank without Discharge Resistors and Reduced Transients," 2023 IEEE International Autumn Meeting on Power, Electronics and Computing (ROPEC), pp. 1-6, 2023, https://doi.org/10.1109/ROPEC58757.2023.10409412.
M. B. Gawande, S. D. Bangar, N. M. Wagh and T. B. Bele, "Power Factor Correction using PLC," 2024 International Conference on Knowledge Engineering and Communication Systems (ICKECS), pp. 1-5, 2024, https://doi.org/10.1109/ICKECS61492.2024.10616624.
M. Ali, F. Rashid, and S. Rasheed, "Power factor improvement for a three-phase system using reactive power compensation," Indonesian Journal of Electrical Engineering and Computer Science, vol. 24, no. 2, pp. 715-727, 2021, https://doi.org/10.11591/ijeecs.v24.i2.pp715-727.
Y. Kabir, Y. M. Mohsin, and M. M. Khan, "Automated power factor correction and energy monitoring system," in Proceedings of the 2017 2nd IEEE International Conference on Electrical, Computer and Communication Technologies, ICECCT 2017, 2017, https://doi.org/10.1109/ICECCT.2017.8117969.
E. H. Currie, "Introduction to Embedded System," in Mixed-Signal Embedded Systems Design: A Hands-on Guide to the Cypress PSoC, pp. 1-34, 2021, https://doi.org/10.1007/978-3-030-70312-7_1.
A. Radovici and I. Culic, "Embedded Systems and Architectures," in Getting Started with Secure Embedded Systems: Developing IoT Systems for micro:bit and Raspberry Pi Pico Using Rust and Tock, pp. 1-26, 2022, https://doi.org/10.1007/978-1-4842-7789-8_1.
W. A. Salah, B. A. Zneid, A. Abu_al_aish, and M. Nofal, "Development of Smart and Portable Controllable Syringe Pump System for Medical Applications," Journal of Engineering and Technological Sciences, vol. 55, no. 3, pp. 300-312, 2023, https://doi.org/10.5614/j.eng.technol.sci.2023.55.3.7.
A. Abu Sneineh and W. A. Salah, "Design and implementation of an automatically aligned solar tracking system," International Journal of Power Electronics and Drive Systems, vol. 10, no. 4, pp. 2055-2064, 2019, https://doi.org/10.11591/ijpeds.v10.i4.pp2055-2064.
V. Gupta, M. Sharma, R. K. Pachauri, and K. N. D. Babu, "A Low-Cost Real-Time IOT Enabled Data Acquisition System for Monitoring of PV System," Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, vol. 43, no. 20, pp. 2529-2543, 2021, https://doi.org/10.1080/15567036.2020.1844351.
Q. Xiang, Y. Hu, Y. Shao, and X. Ye, "Integrated Design of a Multi-Channel Cyclic Data Acquisition Module Circuit," in 2023 3rd International Conference on Electrical Engineering and Mechatronics Technology (ICEEMT), pp. 111-115, 2023, https://doi.org/10.1109/ICEEMT59522.2023.10263228.
A. R. Syafriansyah¹ and R. A. Fatekha, "Prototype of Data Acquisition Module," in Proceedings of the 7th International Conference on Applied Engineering (ICAE 2024), vol. 251, p. 287, 2024, https://doi.org/10.2991/978-94-6463-620-8_22.
M. Matejček and M. Šostronek, "Microcontroller Based Evaluation of Voltage Regulators Efficiency and Their Noise Performance Estimation by Fast Allan Variance Method," Electronics, vol. 13, no. 11, p. 2144, 2024, https://doi.org/10.3390/electronics13112144.
M. S. Rahman, A. Memy, M. A. Mahmud, and S. Siddique, "Automatic Power Factor Measurement and Improvement Using Capacitor Bank," in 2022 IEEE International Power and Renewable Energy Conference, IPRECON 2022, 2022, https://doi.org/10.1109/IPRECON55716.2022.10059553.
M. S. Rahman, A. Memy, M. A. Mahmud and S. Siddique, "Automatic Power Factor Measurement And Improvement Using Capacitor Bank," 2022 IEEE International Power and Renewable Energy Conference (IPRECON), pp. 1-6, 2022, https://doi.org/10.1109/IPRECON55716.2022.10059553.
A. G. Shende, S. W. Khubalkar, and P. Vaidya, "Hardware Implementation of Automatic Power Factor Correction Unit for Industry," in Journal of Physics: Conference Series, vol. 2089, 2021, https://doi.org/10.1088/1742-6596/2089/1/012032.
M. Y. Naqash, Z. J. E. Rashid, Control, and C. Engineering, "PI controller based automatic power factor correction (APFC) using capacitor bank," vol. 19, no. 1, pp. 40-48, 2023, https://doi.org/10.2478/ecce-2023-0006.
D. J. Pandya et al., "Automatic Power Factor Compensation for Industrial Use to Minimize Penalty," 2023 6th International Conference on Contemporary Computing and Informatics (IC3I), pp. 2499-2504, 2023, https://doi.org/10.1109/IC3I59117.2023.10398095.
M. Ayaz, S. M. H. Rizvi, and M. Akbar, "Dynamic Power Factor Correction in Industrial Systems: An Automated Capacitor Bank Control Approach," in 2023 2nd International Conference on Emerging Trends in Electrical, Control, and Telecommunication Engineering, ETECTE 2023 - Proceedings, 2023, https://doi.org/10.1109/ETECTE59617.2023.10396685.
Published
How to Cite
Issue
Section
License
Copyright (c) 2025 Anees Abu Sneineh , Wael A. Salah, Alfian Ma'arif
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
Authors who publish with this journal agree to the following terms:
- Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution License that allows others to share the work with an acknowledgment of the work's authorship and initial publication in this journal.
- Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgment of its initial publication in this journal.
- Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).
This journal is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
